Product ID:LACQUER, ACRYLIC, LOW REFLECTIVE P956
MSDS Date:07/01/1991
FSC:8010
NIIN:01-042-9438
MSDS Number: BMQLP

LENMAR INC.

150 S. CALVERTON ROAD
BALTIMORE, MD 21223
US

Emergency Phone: 301-358-5524

Info Phone: 301-947-2300

Cage: KO656

LENMAR, INC.

BALTIMORE, MD 21223 US

Telephone: 410-947-2300/410-358-5524

Cage: 0BDY9

ETHANOL (ETHANOL) (VAPOR PRESSURE 43.9 MM HG @ 20 C)

CAS: 64-17-5

RTECS: KQ6300000

Fraction By Weight: 8.1%

OSHA PEL 1000 PPM

ACGIH TLV: 1000 PPM

N-BUTYL ACETATE (SARA 313) (BUTYL ESTER, ACETIC ACID)

CAS: 123-86-4

RTECS: AF7350000

Fraction By Weight: 16.9%

OSHA PEL 150 PPM

ACGIH TLV: 150 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 7.7%

OSHA PEL 200 PPM/150 STEL

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

METHYL ETHYL KETONE (2-BUTANONE) (SARA 313) (VAPOR PRESSURE

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 23.6%

OSHA PEL 200 PPM

ACGIH TLV: 200 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ISOPROPANOL (2-PROPANOL) (VAPOR PRESSURE 33 MM HG @ 20 C)

CAS: 67-63-0

RTECS: NT8050000

Fraction By Weight: 3.7%

OSHA PEL 400 PPM/500 STEL

ACGIH TLV: 400 PPM/500 STEL

TALC

CAS: 14807-96-6

RTECS: MW2700000

Fraction By Weight: 4.6%

OSHA PEL 0.2 FIBERS

ACGIH TLV: 0.2 FIBERS

6 OZ G/L.

RTECS: 9999999VO

Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHAL: ANESTHETIC. IRRIT OF RESP
TRACT/ACUTE NERVOUS SYS DEPRESS (HEADACHE/DIZZINESS/STAGGERING
GAIT/CONFUSION/UNCONSCIOUSNESS/COMA). SKIN/EYE: PRIMARY IRRIT.
REPEAT/PROLONG: PERM BRAIN/NERV SYS DAMAG E. CONC/INHALING MATERIAL
MAY BE HARMFUL OR FATAL. ANIMAL STUDIES: CARDIAC SENSITIZATION
(FATAL CHANGES IN HEART *
Explanation of Carcinogenicity:IARC HAS DETERMINED THAT THERE IS
LIMITED EVIDENCE FOR THE CARCINOGENICITY OF CRYSTALLINE SILICA TO
HUMANS.
Effects of Overexposure:*RHYTHMS. MASSIVE EXPOSURE MAY CAUSE MULTIPLE
ORGAN DAMAGE AND/OR DEATH. LONG TERM OVEREXPOSURE: TALCOSIS
(PULMONARY FIBROSIS) MAY LEAD TO SEVERE AND PERMANENT LUNG DAMAGE.

First Aid:INHALATION: REMOVE TO FRESH AIR. IF BREATHING DIFFICULT, GIVE
OXYGEN. CALL DR. EYES: FLUSH IMMED W/COPIOUS QUANTITIES OF RUNNING
WATER FOR 15 MINS MINIMUM. SEE DR. SKIN: WASH AFFECTED AREAS IMMED
W/WA TER. REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE REUSE.
CONSULT DR. INGESTION: CALL DR OR POISON CONTROL CENTER
IMMEDIATELY. IF CONSCIOUS GIVE ONE OR TWO GLASSES OF WATER. DO NOT
INDUCE VOMITING.

Flash Point Method:TCC
Flash Point:21.0F,-6.1C
Lower Limits:1.0
Extinguishing Media:FOAM, ALCOHOL FOAM, CARBON DIOXIDE, DRY CHEMICAL,
WATER FOG.
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE(USE WATER SPRAY TO
COOL CLSD CNTNRS TO PREVENT EXPLOSION). AVOID UNNECESSARY EXPOSURE
TO FUMES. IF EXPOSED, GET IMMED MED AID. USE SCBA
Unusual Fire/Explosion Hazard:DECOMP PROD: TOXIC GASES. KEEP CNTNRS
TIGHTLY CLSD. ISOLATE FROM HEAT/IGNIT SOURCES. CLSD CNTNRS EXPLOD
W/HEAT. DO NOT APPLY TO HOT SURFACES. DONT MIX W/SOLVNTS

Spill Release Procedures:REMOVE ALL IGNITION SOURCES. MOP UP SPILLS OR
ADD ABSORBANT.USE ADEQUATE VENTILATION. MOVE LEAKING CNTNRS
OUTDOORS, OBSERVING PRECAUTIONS W/REGARD TO FIRE, SPARK & FLAME
HAZARD. RUNOFF TO WATERWAY CRE ATES FIRE HAZARDS; NOTIFY FIRE &
HEALTHAGENCIES.

Handling and Storage Precautions:STORE IN WELL-VENTILATED WAREHOUSE.
KEEP OUT OF DIRECT SUNLIGHT/OTHER HEAT SOURCE. KEEP CONTAINERS
CLOSED. NO SMOKING. DO NOT INGEST (HARMFUL/FATAL).
Other Precautions:GROUND CNTNRS WHEN POURING. AVOID LIQ FREE FALL OF
OVER A FEW IN. CLOSE CNTNR AFTER USE/USE ORIG CNTNRS ONLY. AVOID
SKIN CONTACT/BREATH VAPORS. NO HEAT/INGNIT SOURCES. USE
NON-SPARKING TOOLS/EXPLO PRO OF EQUIP. USE ONLY W/ADEQUATE VENT.

Respiratory Protection:OPEN AREAS: MECH FILTER RESPIRATOR. RESTRCT
VENT: CHEM/MECH FILTER RESPIRATOR. CONFINED: AIRLINE RSPRTR/HOOD.
WEAR RSPRTR DURING/AFTER APPLICATION UNLESS VAPOR/MIST BELOW TLV.
FOLLOW RESPIRATOR MFR'S DIRECTIONS FOR RESPIRATOR USE.
Ventilation:USE APPROVED SPRAY BOOTH. PROVIDE GENERAL DILUTION/LOCAL
EXHST VENTILATION (VOL/PATTERN TO KEEP CONC BELOW TLV).
Protective Gloves:REQ FOR PROLONGED OR REPEATED CONTACT.
Eye Protection:SPLASH PROOF GOGGLES.
Other Protective Equipment:NONE REQUIRED.
Work Hygienic Practices:NONE REQUIRED.
Supplemental Safety and Health
NOTE TO DR: IF MORE THAN 2.0 ML PER KG HAS BEEN INGESTED & VOMITING HAS
NOT OCCURRED, EMESIS SHOULD BE INDUCED W/SUPERVISION. KEEP VICTIM'S
HEAD BELOW HIPS TO PREVENT ASPIRATION. IF SYMPTOMS (IE, LOSS OF
GAG REFLEX, CONVULSIONS OR UNCONSCIOUSNESS BEFORE EMESIS), CONSIDER
GASTRIC LAVAGE USING CUFFED ENDOTRACHEAL TUBE.

Boiling Pt:B.P. Text:173 TO 302F
Vapor Density:> AIR
Spec Gravity:8.81 LB/GL
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:71

Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS
Stability Condition to Avoid:TEMPERATURES IN EXCESS OF 150 F IN CLOSED
CONTAINER. EXPOSURE TO HEAT, SPARKS, OPEN FLAME AND HOT SURFACES.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE

Waste Disposal Methods:RECLAIM MATERIAL, INCINERATE OR USE SANITARY
LANDFILL METHOD OF DISPOSAL, IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS. DO NOT INCINERATE CLOSED CONTAINERS. SEAL DRUMS
TIGHTLY.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.